Edelbrock Automobile Parts TRX300EX User Manual

INSTRUCTION SUPPLEMENT  
1993-LATER HONDA  
TRX300EX  
Figure 1.  
Twist Throttle  
Removing Stock Carb and Cables  
1. Remove stock thumb throttle  
housing from handle bar end.  
1. Remove seat/fender assembly and fuel  
tank.  
2. Install cables into supplied twist  
throttle housing by clamping the end  
with the plastic elbows into throttle  
housing.  
2. Remove throttle cables paying close  
attention to routing.  
3. Remove thumb throttle housing if you are  
installing a twist throttle.  
3. Install the pull (see figure 3 for cable  
identification), cable end into the 8:00  
position and the idle cable end into the  
11:00 position on the cable wheel. See  
Figure 2.  
4. Remove air box.  
5. Remove stock carburetor.  
6. Stuff a clean rag into intake manifold to  
keep debris from entering engine.  
Figure 2.  
Preparing machine for carburetor  
installation  
1. Route the provided throttle cables per  
manufacturer’s recommended procedure,  
routing them the same as the stock cables.  
2. Remove the rubber alignment tabs from  
the manifold using a razor blade or cutters.  
Be very careful not to damage the intake  
manifold!  
Figure 3.  
Thumb Throttle  
1. Thread cable into cable housing ob  
handle bar and install cable end into throttle  
lever. Refer to service manual for assistance  
disassembling and reassembling throttle  
housing.  
Pull Cable  
2. Attach cable into cable wheel with the  
cable end at the 8:00 position of the cable  
wheel, then into bracket. Secure by  
replacing the cable bracket end and phillips  
screw. See Figure 1.  
3. Adjust the pull cable to achieve wide-  
open throttle. Adjust the idle cable to take  
up the slack. When cables are properly  
adjusted, there should be approx. 1/8” of  
free-play in the throttle.  
Edelbrock Carburetor Installation  
 

EFJohnson Two Way Radio 7243 LTR Net Portable UHF User Manual
Estate Clothes Dryer EED4400W User Manual
FieldServer Computer Drive FS 8700 54 User Manual
Fisher Price Baby Toy 77806 User Manual
Fitness Quest Home Gym 2100HR User Manual
Frigidaire Dishwasher 675000800908 User Manual
Frigidaire Microwave Oven FFCE2278L S User Manual
GE Double Oven JGRP17 User Manual
GE Washer WBSR3140G User Manual
GE Water System GXSF40H User Manual